Red-D-Arc D502K 5+2 Spécifications télécharger pdf (Page 30)

OM-228 921 Page 26

5-9. Engine Prestart Checks

 Check all engine fluids daily.

Engine must be cold and on a level surface.

Unit is shipped with 20W break-in oil. The

Automatic shutdown system stops engine if

oil pressure is too low or coolant tempera-

ture is too high.

 This unit has a low oil pressure shut-

down switch. However, some condi-

tions may cause engine damage before

the engine shuts down. Check oil level

often and do not use the oil pressure

shutdown system to monitor oil level.

Follow run-in procedure in engine manual.

If unburned fuel and oil collect in exhaust

pipe during run-in, see Section 10.

Fuel

NOTICE − Do not use gasoline. Gasoline

will damage engine.

NOTICE − Do not use ether to start engine.

Add fresh diesel fuel before starting to pre-

vent air from entering the fuel system (see

engine maintenance label for fuel specifica-

tions). Leave filler neck empty to allow room

for expansion.

Engine stops if fuel level is low.

Oil

After fueling, check oil with unit on level sur-

face. If oil is not up to full mark on dipstick,

add oil (see maintenance label).

NOTICE − Engine may use oil and wets-

tacking may occur during run-in. Check oil

several times daily during run-in.

Coolant

Check coolant level in radiator before start-

ing unit the first time. Add coolant if below

bottom of filler neck (see Section 5-10 for ra-

diator filling instructions).

Check coolant level in recovery tank daily.

If coolant is below Cold Full level, add cool-

ant until level in tank is between Cold Full

and Hot Full levels. If recovery tank coolant

level was low, check coolant level in radiator

(see Section 5-10).

Engine coolant is a mixture of water and

ethylene glycol base antifreeze. A solution

of 50% antifreeze and 50% water must be

used in this engine. Do not use 100% anti-

freeze or severe damage will occur.

Keep radiator and air intake clean.

NOTICE − Incorrect engine temperature

can damage engine. Do not run engine with-

out a properly working thermostat and ra-

diator cap.

 To improve cold weather starting:

Use Engine Start/Preheat switch to op-

erate glow plug (see Section 6-1).

Keep battery in good condition. Store

battery in warm area.

Use fuel formulated for cold weather

(diesel fuel can gel in cold weather).

Contact local fuel supplier for fuel in-

formation.

Use correct grade oil for cold weather

(see Section 8-1).

Full

Diesel

Full

Full

Capacity: w/Overflow

Tank 10 qt (9.5 L)

Check radiator coolant

level when fluid is low in

recovery tank.

Remove air bleed screw

when filling radiator.

See Section 5-10.

Full

Coolant Recovery

Tank

804 583-A

1 2 ... 25 26 27 28 29 30 31 32 33 34 35 ... 79 80

Commentaires sur ces manuels

Pas de commentaire